Cabin

Step 1: Preparing Net House and Shelves

The net house should be approximately 3m high, 4.5m wide, and 8m long, though dimensions may vary based on local conditions.
The structure should be covered with a waterproof tarpaulin. An internal layer of orchid netting or wire mesh can be used to help regulate temperature and humidity. It is crucial to ensure proper ventilation.

Growing shelves made of bamboo or iron should feature 3-4 tiers spaced 0.5m apart to allow for easy maintenance and harvesting.

Step 2: Preparing Rice Straw

Select fresh, disease-free straw that shows no signs of rot.
Ensure the straw is not contaminated with salinity or pesticides.
Use bales weighing approximately 14–16 kg or loose straw piles.

Step 3: Soaking of Straw & Straw Treatment

Prepare a straw-soaking tank near the composting area for convenience.
Use a waterproof tarpaulin to construct the soaking tank, with size depending on site conditions.
The ground beneath the tank must be flat and free of sharp debris that could tear the liner.

Prepare lime water: Fill the tank with water to a height of about 20cm, then add lime. Stir well and use pH paper to test the solution (aiming for a pH of 13-14). Usually, about 5 kg of lime is added per 1 cubic meter of water.
After soaking the straw for approximately 10 minutes, remove and drain it. The straw should turn bright yellow after the lime water treatment.

Step 4: Stacking and Turning

Arrange the straw in layers, placing a banana plant stalk in the middle for aeration, watering each layer, and compressing it by foot to soften it and absorb water (each layer should be 20-30 cm thick). Additionally, sprinkle a layer of lime to eliminate competing fungi. Remove any woody stalks or debris from the watered straw.
Continue stacking layers until the compost pile reaches the desired size. Use at least 1 ton of raw straw to achieve a pile roughly 1.2–1.5m high, 1.5m wide, and 1.5m long. Remove the banana plants from the middle of the pile to create ventilation shafts. Ensure the pile is well-ventilated and cover it with a waterproof tarp to maintain moisture and heat.

After 7 days, perform the first turning, rotating the material from the outside in. Add water if dry and compact the pile (if there is excess water, compacting is not necessary). The humidity level must reach 70-75%, and the temperature should exceed 70°C.
After 10 days, perform the second turning. After 17 days of incubation, the straw is ready for growing mushrooms.

Step 5: Preparing Mushroom Spawn

If using rice husk spawn, select bags with uniform white mycelium (silk) and a pleasant aroma. The spawn is separated and mixed with mycelium-stimulating yeast at the recommended ratio.

Step 6: Putting Compost Straw on Shelves

Transfer the composted straw to the shelves in the growing house, breaking it apart and compressing it firmly into the beds.
Mix mushroom spawn with yeast to stimulate growth and supplement nutrition. Spread the mixture evenly over the surface at a rate of 200 g/m2.

Incubate the mycelium for 3 days. Regularly monitor the net house temperature and humidity to manage misting and ventilation.
After 3 days, apply vermicompost fertilizer at a rate of 2 kg/m2.

Step 7: Caring and Watering

During the incubation period, it is essential to monitor the temperature and humidity of the net house.
The suitable temperature for the mycelium stage is 15-40°C, with humidity maintained at 50-70%.
For the fruiting stage, the temperature should be 25-30°C, with humidity between 80-100%.
At this stage, the substrate does not require abundant moisture. If the temperature is high and the humidity is low, misting the net house is recommended.

After 7 days, sprinkle water generously to stimulate the mycelium to form fruiting bodies. Combine watering with 12 hours of light exposure to encourage simultaneous pinning.
Additionally, 0.05% sodium acetate (1 L/m2) can be added to promote better growth.

Step 8: Harvesting

Harvest straw mushrooms at the “egg” stage. Harvesting should be done twice per day, in the morning (5-6 am) and in the afternoon (5-6 pm), to ensure optimal quality, productivity, and selling price.
There are generally 2 harvests. The first harvest lasts 4 days. Then, continue maintenance for about 5-6 days until the second flush appears. The second harvest will last about 3 days.

Step 9: Cleaning the Net House

After harvesting, the substrate can be composted into organic fertilizer.
Open the tarpaulin to ventilate the net house and use lime to disinfect the surfaces. Fallow the area for at least 1 month before planting the next crop.

Select language